Kawasaki Vulcan 750 Forum : Kawasaki VN750 Forums - Reply to Topic
Electrical
Where does this wire go?
Includes Electrical mods, Lights, Stator,
Rectifier, Diagrams, etc

Thread: Hudini Charging Reply to Thread
Title:
Message:
Trackback:
Send Trackbacks to (Separate multiple URLs with spaces) :
Post Icons
You may choose an icon for your message from the following list:
 

Register Now



In order to be able to post messages on the Kawasaki Vulcan 750 Forum : Kawasaki VN750 Forums forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

Once registered, your User Name"cannot be changed". We can make exceptions within 7 days, but after that, it is set in stone.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










  Additional Options
Miscellaneous Options

  Topic Review (Newest First)
06-03-2016 01:53 AM
thtanner Best of luck, let us know how it goes
06-02-2016 10:47 PM
Kristoco Well I've messed around too long with the charging issue. I ordered the stator and seal and it should!be here within a week.

Thank you for all the info folks!

Kristoco
05-28-2016 04:15 PM
Kristoco Well here's an update. I did the blue wire mod as well as the 2 wire mod and that went well yet now my charging system is not charging at idle (11.9) and yet when running I'm getting 12.3 at best 12.4. Tested the r&r and it gave me 1 on a 200 Ω meter as it should.

I'm definitely not a wire guy and wonder what may be next to look at.


Thank you.

Kristoco
05-22-2016 01:45 PM
Kristoco Thank you! I'm degoated, ear shaved and have a new r&r. Took all of dash off n rewired for new Speedo heat gauge and volt meter. Testing again now.
05-22-2016 01:06 PM
thtanner Test both the regulator and the stator (both hot and cold).

Stator test: https://www.vn750.com/forum/19-electr...ator-pics.html
R/R test: https://www.vn750.com/forum/40-electr....html#post5494

Also, check grounds. Clean where they connect up and tighten them back down, etc. A bad ground can cause all sorts of 'weird' stuff.

There are 'mods' to wiring but I'm not sure what has or hasn't been done to your wiring harness. The two-wire mod may help.
05-22-2016 12:32 PM
Kristoco
Hudini Charging

Well I'm stumped for sure. I've had my wire harness cleaned up and all the extra wires I didn't need were removed and the dash is gone as well and I'm keyless.

What's happening is I start it and it shows that it's charging and accurately. When I drive 1-3 miles it starts to discharge at 11.9 yet not much less than 11.5. If I stop and let it set 5 minutes or so and the charging will go back to normal and then the cycle repeats. I also have a dimming of the speedometer when I use either brake. Any info with this is greatly appreciated because my testing shows it's totally fine.

Thank you,

Kristoco

Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

 
For the best viewing experience please update your browser to Google Chrome